ANALYSIS OF IMPROVEMENT CAUSING DAMAGE TO CYLINDER LINERS AND PISTON RODS IN VEHICLE MODELS (F65 # -3SZ)

Cecep Deni Mulyadi

Abstract


Abstract: Cases that occur complaining about the engine on the vehicle is abnormal, both in idling and high rpm, when the initial inspection is carried out, there appear to be abnormal symptoms on the vehicle's engine.So it needs repairs to the vehicle where there is a problem in the vehicle, which complains about the abnormal state of the engine both the state of idling or middle and high rpm.After doing repairs, the problems that occur occur. The water hammer is caused by a cowl top seal that has no locking clip and water filter assembly. As a result of the water hammer being produced, there is damage to the components inside the cylinder block, namely the cylinder liner and piston rod.

Keywords: Abnormal, When Idling, High Rpm


Full Text:

PDF

References


Toyota Astra Motor. 1995. New Step 1 Training Manual. Jakarta Toyota Astra Training Center.

Toyota Astra Motor. 1995. New Step II Training Manual. Jakarta Toyota Astra Training Center.

Toyota Motor (2015). MODEL Handbook (F65 # -3SZ) repair. Jakarta: PT. Astra Toyota motorbike.

Murdjani. (2013). Analysis of Cylinder Block Damage with Deck Clearance Measurement Method. INTEKNA Journal (Special Edition), Year XIII, No. 3, December 2013: 212 - 218. Banjarmasin State Polytechnic Mechanical Engineering Department

Zulkarnain Rendy. (2018). 750-7 Pc Engine Cylinder Liner Damage Case Study with PT Saptaindra Sejati Site Adaro. Balikpapan State Polytechnic Mechanical Engineering Department.

Raharjo Samsudi, Rubiyanto. (2008). Wear Analysis on Cylinder Walls. Traction. Vol. 7. No. I 'June 2008. ISSN: 1693-3451.

Espadafor, F. J., J.B. Villanueva et al. "Analysis of a diesel generator cylinder failure", Engineering Failure Analysis, 17 (2010), p.913-925

Didit Sumardiyanto, Syahrial Anwar. (2017). "The Effect of Piston Ring Wear on Machine Performance", Journal of Mechanical Engineering Study Vol. 2 No. April 1, 2017. Faculty of Engineering, Department of Engineering, University Engineering August 17, 1945 Jakarta.




DOI: https://doi.org/10.31848/ensains.v2i2.241

Refbacks

  • There are currently no refbacks.


Creative Commons License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License. View My Stats